Impact of turning waste on performance and energy balance in thermophilic solid-state anaerobic digestion of agricultural waste
Copyright © 2019 Elsevier Ltd. All rights reserved.
| Veröffentlicht in: | Waste management (New York, N.Y.). - 1999. - 87(2019) vom: 15. März, Seite 183-191 |
|---|---|
| 1. Verfasser: | |
| Weitere Verfasser: | , , , |
| Format: | Online-Aufsatz |
| Sprache: | English |
| Veröffentlicht: |
2019
|
| Zugriff auf das übergeordnete Werk: | Waste management (New York, N.Y.) |
| Schlagworte: | Journal Article Mixing frequency Organic matter degradation Oxidation-reduction potential Simplified solid-state anaerobic digestion Biofuels Sewage Methane OP0UW79H66 |
| Zusammenfassung: | Copyright © 2019 Elsevier Ltd. All rights reserved. Mixing is an important operation in solid-state anaerobic digestion (SS-AD) to improve the mass transfer of the solid phase. This study proposed simple turning by loader in common garage-type digester without commonly used mixer or percolation system (simplified SS-AD). In simplified-SS-AD, turning is conducted in open condition. Thus, oxidation of anaerobic sludge during turning would influence digestion performance. Therefore, in this study, the effect of turning wastes by mixing during digestion on a simplified SS-AD fed with rice straw and pig urine was investigated. Four different mixing frequency levels-no mixing (M0) and mixing once a day (M-1/1), once every 3 days (M-1/3) and once a week (M-1/7)-were conducted. Methane yields of M0, M-1/3 and M-1/7 were comparable with each other. Methane yield and lag period of M-1/1 were approximately 61% and 155% of M0 (351.2 mL/g VS and 4.7 days), respectively. Furthermore, the chemical oxygen demand (COD) of acetate accumulated in the digestate of M-1/1 was comparable to the difference in the COD of methane production between M-1/1 and the other treatments. Mixing every day also resulted in a higher oxidation-reduction potential and carbon dioxide content. These findings suggest that methanogenesis was inhibited in M-1/1 by frequent mixing in the atmosphere. Net energy analysis of SS-AD plant operation showed that M0 can obtain the highest net energy gain, whereas net energy production of M-1/7 was reduced by rewarming after mixing. Therefore, no mixing is the most effective approach for the proposed simplified process |
|---|---|
| Beschreibung: | Date Completed 12.09.2019 Date Revised 12.09.2019 published: Print-Electronic Citation Status MEDLINE |
| ISSN: | 1879-2456 |
| DOI: | 10.1016/j.wasman.2019.02.012 |